Volvo sunroof repair




Volvo sunroof repair

Article Navigation:
  • Photo
  • Volvo Sunroof Repair | Moving bits around to make noise
  • Video
  • RELATED PAGES
  • I love my sunroof, but I hate it when something goes wrong with it. My last S60 had the sunroof busted by an errant football -- that was $ to.

    Volvo Sunroof Seal ( S70 V70) - Genuine Volvo being said, there are some common problems with power sunroofs, including sealant issues.

    Member, atikovi was having trouble with the sunroof not working properly and decided to go to a junk yard and retrieve an entire unit- frame.

    Volvo sunroof repair

    Volvo sunroof repair

    If the glass comes with the mounting rails then its a 10 minute procedure to swap it out. I appreciate you taking the time and effort to put this informative article together. I had a few broken parts. I went out to get some dinner, and some time during the 1.

    Volvo sunroof repair

    Volvo sunroof repair

    Volvo sunroof repair

    Volvo sunroof repair

    Volvo sunroof repair

    I love my sunroof, but I hate it when something goes wrong with it. I never had any problems with my current S60 until last week. I went out to get some dinner, and some time during the 1. The sunroof would barely close and would actually get stuck and reverse. I took it out to the Volvo dealer where I bought the car and they looked at it for an hour and declared there was nothing wrong, the tracks just bind up after a while and all they did was add lubrication.

    The very next day I happened to be opening my passenger side door to get something and noticed that a piece of metal behind the sunroof was skewed, obviously broken on one side.

    Volvo sunroof repair

    Today I decided to pull it apart myself and take a look. It took me about 20 minutes to get the glass out and take apart the mechanism to find the problem. The plastic tab right arrow below holds the metal arm on that actually attaches the slider to the sunroof.. This is as far as I had to go to get to the problem. You can subscribe via RSS 2. You can comment below , or link to this permanent URL from your own site. Leave it to you to take something a part and figure it out yourself, haha.

    When my selector gate broke, one of the sides would get jammed because only one side was being pulled forward.. If you can, look back into the recess where the glass slides and make sure nothing looks out of place or crooked like the crossbar.

    Volvo sunroof repair

    I only need to take out my slider. Is all this necessary? Nice write-up and picture set. Where did you get the replacement part? I have a 98 V70 with a broken assembly that looks similar to yours. I can get to it but have no idea how to describe the part to the service desk. Is there a service manual that contains more information? I took the part into the local Volvo dealer and had them pull up the sunroof assembly schematic to find a match.

    The parts vary slightly by model, so make sure you get the right one. Might want to pick up some white lithium grease to put in the track after you install the new part. I have a problem with the slider. It got stuck and all the little plastic elements that go on a track are broken. There are also two plastic parts on each side that hold glass and slider together and they are broken too.

    Where should I look for these parts?? If you have a friendly dealer then they should be able to go to the parts department and ask them for the parts. The local dealer here even sent me the exploded parts diagram so I could look for the parts I needed.

    Volvo sunroof repair

    I broke the glass itself, dealer wants Think it would be cheaper to do myself. Will it be a pain? If the glass comes with the mounting rails then its a 10 minute procedure to swap it out. Hello, I just seemed to have broken my sunroof the same way. I tried to play with it a little yesterday but ran out of time. Would you still have that blown up sunroof diagram? I also wonder how much all those little extra parts cost.

    I will post it on Flickr or something if I run across the diagram.. The description and photos you have posted are very helpful, and hopefully I will able to fix the problem myself, and I would like to thank-you for posting them. Is this the same procedure I would follow if I need to replace the sunshade under the sunroof glass? During a reall cold snap the shade was pushed on while trying to get something out of the back seat, there was a snapping noise and now the shade will not slide forward or backward.

    Roof head ceiling liner and sunroof removal, Volvo and other cars - Auto Repair Series



    • Подписаться по RSSRSS
    • Поделиться VkontakteVkontakte
    • Поделиться на FacebookFacebook
    • Твитнуть!Twitter

    Leave a Reply

    Return to Top ▲TOP ▲